辐照对黄原胶分子量、结构及流变性能的影响

doi:10.3864/j.issn.0578-1752.2011.21.014

摘要/Abstract

摘要： 【目的】探讨辐照剂量对黄原胶分子量、分子量分布、结构、流变性能的影响，为辐照技术在黄原胶及其它多糖分子修饰上的应用提供理论依据。【方法】以60Co-γ射线对固态黄原胶进行不同剂量 (0—400 kGy) 的辐照，采用凝胶渗透色谱（GPC）、X-射线衍射(XRD)、红外扫描(FTIR)、紫外-可见光扫描(UV-vis)以及流变仪等对样品的分子量、分子量分布、结构以及流变性能进行表征和测定。【结果】低于10 kGy剂量的辐照使黄原胶分子量增大，分子量分布变窄；辐照剂量高于10 kGy后，分子量随剂量增大而降低，而分子量分布先变宽，在50 kGy时达到最大后，又趋于变窄。X-射线衍射、红外及紫外分析表明，辐照造成黄原胶分子上的部分糖苷键发生断裂，引起结晶度的变化，并在链端产生少量羰基，但其基本化学结构和晶体结构保持稳定。辐照处理后，黄原胶溶液的表观黏度与剪切速率、剪切时间和温度之间的关系均发生了显著变化。【结论】γ射线可同时作用于黄原胶的结晶区和无定形区，引发聚合和降解两种辐照效应，并对其分子量、分子量分布造成显著影响，进而使其流变性能发生改变。

关键词: 黄原胶, 辐照, 分子量, 分子量分布, 结构, 流变性能

Abstract: 【Objective】 The effects of irradiation dose on the molecular weight, molecular weight distribution, structures and rheological behaviour of xanthan gum were investigated for the purpose of applying irradiation technique to molecular modification of xanthan gum and even other polysaccharides. 【Method】 Xanthan gum was irradiated in dry state at different doses (0-400 kGy) of 60Co γ-rays to investigate the changes of the molecular weight, molecular weight distribution, structures and rheological behaviour of irradiated xanthan gum by using gel permeation chromatography (GPC), X-ray diffraction (XRD), fourier-transform infrared spectra (FTIR), ultraviolet-visible spectral (UV-vis) and rheometer. 【Result】 Results showed that the molecular weight and crystallinity of xanthan gum increased at 10 kGy, then decreased gradually with increasing irradiation dose. Contrary to it, molecular weight distribution of irradiated xanthan gum decreased at 10 kGy, then increased gradually to maximum value at 50 kGy, and then decreased with irradiation dose. FT-IR spectra and XRD indicated that γ-irradiation introduced no significant changes into the structure and crystal texture but UV spectra showed a distinct absorption peak at about 265 nm, increasing with irradiation dose, which was attributed to the formation of carbonyl groups or double bond. The relationship between apparent viscosity of xanthan gum solution and shearing rate, shear time and temperature were varied significantly. 【Conclusion】 γ-irradiation can act simultaneously on crystallization area and amorphous area of xanthan gum, and cause polymerization or degradation of xanthan gum molecule, thus the molecular weight and molecular weight distribution, and then the rheological behaviour of irradiated xanthan gum were obviously changed.

Key words:

xanthan gum, irradiation, molecular weight, molecular weight distribution, structure, rheological behaviour

李彦杰, 哈益明, 王锋, 李咏富. 辐照对黄原胶分子量、结构及流变性能的影响[J]. 中国农业科学, 2011, 44(21): 4454-4463.

LI Yan-Jie, HA Yi-Ming, WANG Feng, LI Yong-Fu. Effect of Irradiation on the Molecular Weight and Structure and Rheological Behaviour of Xanthan Gum[J]. Scientia Agricultura Sinica, 2011, 44(21): 4454-4463.

0
/ / 推荐

导出引用管理器 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

链接本文: https://www.chinaagrisci.com/CN/10.3864/j.issn.0578-1752.2011.21.014

https://www.chinaagrisci.com/CN/Y2011/V44/I21/4454

参考文献

[1]Sandford P A, Baird J, Cottrell I W. Xanthan gum with improved dispersibility. Solution properties of polysaccharide. Journal of the American Chemical Society, 1981, 150: 31-41.

[2]Cripps R E, Holt M S, Sommerville H J. Xanthanase enzyme and its production. Europen Patent Application, EP 0030393 A1, 1981.

[3]Ishizaks S, Sugawara I, Hasutna T, Morisawa S, Moller G. Immune responses to Xanthan gum I. The characteristics of Iymphocyte activation by Xanthan gum. European Journal of Immunology, 1983, 13: 225-231.

[4]Shimada K F, ikaum K, Yahara K, Nakamuta T. Antioxidative properties of Xanthan on the autoxidation of soybean oil in cyclodextrin emulsion. Journal of Agricultural and Food Chemistry, 1992, 40: 945-948.

[5]李信, 许雷. 黄原胶的主要理化性能及其抗氧化特性的初步研究. 生物技术通报, 1997(4): 33-37.

Li X, Xu L. Study on the antioxidant and some properties of xanthan gum. Letters in Biotechnology, 1997(4): 33-37. (in Chinese)

[6]黄成栋, 王红荣, 白雪芳, 杜昱光, 李宪臻. 黄原胶降解菌的筛选及其降解酶性质的研究. 微生物学通报, 2005, 32(1): 32-37.

Huang C D, Wang H R, Bai X, Du Y G, Li X Z. Screening of a xanthan-degrading bacteriumand characterization of the xanthanase. Microbiology, 2005, 32(1): 32-37. (in Chinese)

[7]何晓燕, 张利英, 白雪芳, 杜昱光, 李宪臻. 黄原胶寡糖生物活性的研究. 微生物学通报, 2005, 32(3): 87-90.

He X Y, Zhang L Y, Bai X, Du Y G, Li X Z. Bioactivity of oligosaccharide produced by depolymerisation of Xanthan with Xanthan-degrading enzyme. Microbiology, 2005, 32(3): 87-90. (in Chinese)

[8]Nankai H, Hashimoto W, Miki H, Kawai S, Murata K. Microbial system for polysaccharide depolymerisation: enzymatic route forxanthan epolymerisation by Bacillus sp. strain GL-1. Applied and Environmental Microbiology, 1999, 65(6): 2520-2526.

[9]关琛, 方波, 侯玉梅, 黄春兰, 朱叶. 降解瓜胶与降解黄原胶的协同凝胶化及其流变性研究. 食品科技, 2007(3): 26-31.

Guan C, Fang B, Hou Y M, Huang C L, Zhu Y. Synergistic gelation and rheology of degraded guar with degraded xanthan. Food Science and Technology, 2007(3): 26-31. (in Chinese)

[10]姚珺斐, 方波, 卢拥军, 浦柳花. 降解黄原胶与降解魔芋胶形成的凝胶体系的流变性. 华东理工大学学报:自然科学版, 2006, 32(8): 902-905.

Yao J F, Fang B, Lu Y J, Pu L H. Rheological Properties for the Gel Formed by Degraded Xanthan and Konjak. Journal of East China University of Science and Technology: Natural Science Edition, 2006, 32(8): 902-905. (in Chinese)

[11]Dintzis F R, Babcock G E, Tobin R. Studies on dilute solutions and dispersion of the polysaccharide from Xanthomonas campestris NRRL B-1459. Carbohydrate Research, 1970, 13(2): 257-267.

[12]Jansson P E, Kenne L, Lindberg B. Structure of the extracellular polysaccharide from Xanthomonas campestris. Carbohydrate Research, 1975, 45: 275-282.

[13]Lee H C, Brant D A. Rheology of concentrated isotropic and anisotropic xanthan solutions.1. A rodlike low molecular weight sample. Macromolecules, 2002, 35: 2212-2222

[14]哈鸿飞, 吴季兰. 高分子辐射化学-原理与应用. 北京: 北京大学出版社, 2002: 3-106.

Ha H F, Wu J L. Polymer Radiation Chemistry - Principles and Applications. Beijing: Peking University Press, 2002: 3-106. (in Chinese)

[15]Czechowska-biskup R, Rokita B, Ulanski P. Radiation-induced and sonochemical degradition of chitosan as a way to increase its fat-binding capacity. Nuclear Instruments and Methods in Physics Research, 2005, 236:383-390.

[16]Hebeksha A, Ei-naggarb A M, Ei-sisia F, Abdel-hafiz S, Ei-salmwi K. Improving the size ability of starch using gamma radiation. Polymer Degradation and Stability, 1992, 36(3): 249-252.

[17]Abu J O, Duodu K G, Minnaar A. Effect of γ-irradiation on some physicochemical and thermal properties of cowpea (Vigna unguiculata L. Walp) starch. Food Chemistry, 2006, 95(3): 386-393.

[18]谢芳, 哈益明, 王锋. 辐照降解技术应用及影响因素分析. 核农学报, 2008, 22(1): 70-73.

Xie F, Ha Y M, Wang F. THE application of radiolysis and analysis of influencing factors. Journal of Nuclear Agricultural Sciences, 2008, 22(1): 70-73. (in Chinese)

[19]Relleve L, Nagasawa N, Luan L Q, Yagi T, Aranilla C, Abad L, Kume T, Yoshii F, Dela R A. Degradation of carrageenan by radiation. Polymer Degradation and Stability, 2005, 87(3): 403-410.

[20]陈浩, 高鹏, 高雅, 杨志荣, 孙群. 辐照降解壳聚糖涂膜对沙糖桔、圣女果和金桔的保鲜作用. 核农学报, 2008, 22(5): 640-644.

Chen H, Gao P, Gao Y, Yang Z R, Sun Q. Effect of irradiaton-degraded chitosan coating on quality and shelf-life of the fruits of Shatang mandarin, Fortunella margarita(Lour)swingle and Lycopersicon esculentum mill.vat.cerasiforme alef. Journal of Nuclear Agricultural Sciences, 2008, 22(5): 640-644. (in Chinese)

[21]李彦杰, 哈益明, 王锋, 李咏富. 辐照对黄原胶分子量及抗氧化活性的影响. 核农学报, 2010, 24(6): 1125-1130.

Li Y J, Ha Y M, Wang F, Li Y F. Effect of gamma-irradiation dose on the molecular weight and antioxidant activity of xanthan gum. Journal of Nuclear Agricultural Sciences, 2010, 24(6): 1125-1130. (in Chinese)

[22]中华人民共和国国家药典委员会. 中国药典2005年版二部. 北京:化学工业出版社, 2005: 附录V H.

Chinese Pharmacopoei Commission. Chinese Pharmacopoeia(2005), Volume 2. Beijing: Chemical Industry Press, 2005: Appendix V H. (in Chinese)

[23]Alsop R M, Vlachogiannis G J. Determination of the molecular weight of clinical dextran by gel chromatography on TSK PW TYPE columns. Journal of Chromatography, 1982, 246:227-240.

[24]Ashok K, Kuldeep S, Munish A. Anthan-g-poly(acrylamide): Microwave-assisted synthesis, characterization and in vitro release behavior. Carbohydrate Polymers, 2009, 76(2): 261-267.

[25]Panida P, Shoji T, Glyn O P. Effects of γ-irradiation on molar mass & properties of konjac mannan. Food Hydrocolloids, 2007, 21(8): 1362-1367.

[26]张本山, 张友全, 杨连生, 于淑娟. 淀粉多晶体系结晶度测定方法研究. 华南理工大学学报:自然科学版, 2001, 29(5): 55-58.

Zhang B S, Zhang Y Q, Yang L S, Yu S J. A method of determining crystallinity of starch in multi crystal system. Journal of East China University of Science and Technology: Natural Science Edition, 2001, 29(5): 55-58. (in Chinese)

[27]Salah B R, Besbes S, Kacem C, Ali R, Hammadi A, Claude D, Christophe B. Rheological and physical properties of date juice palm by-product (Phoenix dactylifera L.) and commercial xanthan gums. Journal of Texture Studies, 2010, 41(2): 125-138.

[28]Su L, Ji W K, Lan W Z, Dong X Q. Chemical modification of Xanthan gum to increase dissolution rate. Carbohydrate Polymersth, 2003, 53: 497-499.

[29]Kiosseoglou A, Papalamprou E, Makri E, Doxastakis G., Kiosseoglou V. Functionality of medium molecular weight xan an gum produced by Xanthomonas campestris ATCC 1395 in batch cultures. Food Research International, 2003, 36: 425-430.

[30]金日光. 高聚物流变学及其在加工中的应用. 北京: 化学工业出版社, 1986.

Jin R G. Macromolecule Polymer Rheology and Its Application in Processing. Beijing: Chemical Industry Press, 1986. (in Chinese)

[31]Milas M, Rinaudo M. Conformational investigation on the bacterial polysaccharide xanthan. Carbohydrate Research, 1979, 76: 189-196.

[32]López M J, Vargas-García M C, Suarez-Estrella F, Moreno J. Properties of xanthan obtained from agricultural wastes acid hydrolysates. Journal of Food Engineering, 2004, 63(1): 111-115.