Camembert干酪成熟过程中的质构和流变学特性

doi:10.3864/j.issn.0578-1752.2013.19.020

中国农业科学 ›› 2013, Vol. 46 ›› Issue (19): 4149-4156.doi: 10.3864/j.issn.0578-1752.2013.19.020

Camembert干酪成熟过程中的质构和流变学特性

于华宁12, 王嘉悦3, 杭锋1, 刘振民1, 李云飞2, 郭本恒1, 梅俊2, 夏永军1, 侯建平1

1.光明乳业股份有限公司/乳业生物技术国家重点实验室，上海 200436
2.上海交通大学农业与生物学院食品科学与工程系，上海 200240
3.华东理工大学生物工程学院食品科学与工程系，上海 200237

收稿日期:2013-03-18 出版日期:2013-10-01 发布日期:2013-06-07
通讯作者: 通信作者刘振民，E-mail：liuzhenmin@brightdairy.com
作者简介:于华宁，E-mail：yuhuaning1981@126.com
基金资助:
国家“十二五”科技支撑计划项目（2013BAD18B02）、上海市闵行区产学研合作计划项目（2012MH156）

Texture and Rheological Properties of Camembert Cheeses During Ripening

YU Hua-Ning-12, WANG Jia-Yue-3, HANG Feng-1, LIU Zhen-Min-1, LI Yun-Fei-2, GUO Ben-Heng-1, MEI Jun-2, XIA Yong-Jun-1, HOU Jian-Ping-1

1.Bright Dairy & Food Co., Ltd./State Key Laboratory of Dairy Biotechnology, Shanghai 200436
2. Department of Food Science & Technology, School of Agriculture and Biology, Shanghai Jiaotong University, Shanghai 200240
3.Department of Food Science & Technology, School of Biotechnology, East China University of Science and Technology, Shanghai 200237

Received:2013-03-18 Online:2013-10-01 Published:2013-06-07

摘要/Abstract

摘要： 【目的】研究Camembert干酪成熟过程中质构和流变学特性随成熟期的变化。【方法】利用TPA（Texture Profile Analysis）分析干酪不同部位的质构特性，包括硬度、黏着性、弹性、内聚性、咀嚼性和胶性等功能特性的变化，利用流变仪测定干酪成熟过程中的弹性模量G’、黏性模量G’’以及损失角δ的变化，利用SAS统计软件分析结果。【结果】成熟时间对Camembert干酪的pH和水分活度影响显著（P＜0.05），对水分含量影响不显著（P＞0.05）；在成熟期内，干酪表面和芯部的质构和流变学特性存在显著差异（P＜0.05）；随成熟期延长，干酪表面的硬度、胶性和咀嚼性呈现下降趋势，而黏着性则呈现增长趋势；干酪芯部的硬度呈先增加后降低的趋势，胶性和咀嚼性呈下降趋势，而黏着性则呈上升趋势；干酪不同位置的G’和G’’差异显著（P＜0.05），干酪芯部的G’和G’’大于干酪表面；干酪芯部的G’和G’’在成熟过程中先增加后降低。【结论】干酪成熟过程中的质构和流变学特性变化与成熟时间密切相关。

关键词: Camembert干酪 , 质构 , 流变学特性 , 成熟

Abstract: 【Objective】 Changes of textural and rheological properties of camembert cheeses were studied during their ripening. 【Method】 Textural properties of different parts of camembert cheeses, including hardness, adhesiveness, springiness, cohesiveness, chewiness and gumminess, were analyzed using Texture Profile Analysis method. Rheological properties including elastic modulus (G’), viscous modulus (G’’) and loss angle (δ), were measured by rheometer and the results were statistically analyzed by SAS software. 【Result】 Water activity and pH of camembert cheeses were significantly affected by ripening time (P＜0.05), but the effect of moisture content was not significant (P＞0.05). During ripening, textural and rheological properties of inner parts of camembert cheeses were significantly different from that of the rind. Hardness, chewiness and gumminess of inner parts decreased with ripening time, but adhesiveness increased. Hardness of the rind increased first but then decreased with ripening time, chewiness and gumminess decreased, but adhesiveness increased. The G’ and G’’ were significantly different among different parts of cheeses (P＜0.05), and the G’ and G’’ of inner parts were bigger than those of the rind. The G’ and G’’ of inner parts increased first but then decreased with ripening time. 【Conclusion】 The textural and rheological properties of camembert cheeses during ripening were mostly correlated with ripening time.

Key words: Camembert cheese , texture , rheological properties , ripening

于华宁12, 王嘉悦3, 杭锋1, 刘振民1, 李云飞2, 郭本恒1, 梅俊2, 夏永军1, 侯建平1. Camembert干酪成熟过程中的质构和流变学特性[J]. 中国农业科学, 2013, 46(19): 4149-4156.

YU Hua-Ning-12, WANG Jia-Yue-3, HANG Feng-1, LIU Zhen-Min-1, LI Yun-Fei-2, GUO Ben-Heng-1, MEI Jun-2, XIA Yong-Jun-1, HOU Jian-Ping-1. Texture and Rheological Properties of Camembert Cheeses During Ripening[J]. Scientia Agricultura Sinica, 2013, 46(19): 4149-4156.

0
/ / 推荐

导出引用管理器 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

链接本文: https://www.chinaagrisci.com/CN/10.3864/j.issn.0578-1752.2013.19.020

https://www.chinaagrisci.com/CN/Y2013/V46/I19/4149

参考文献

[1]郭本恒.干酪. 北京: 化学工业出版社, 2003.

Guo B H. Cheese. Beijing: Chemical Industry Press, 2003. (in Chinese)

[2]Foegeding E, Drake M. Invited review: sensory and mechanical properties of cheese texture. Journal of Dairy Science, 2007, 90(4): 1611-1624.

[3]高辉, 郑志强, 赵征, 尹艳军, 宋小青, 杨凯. Camembert干酪成熟期间理化特性研究. 食品研究与开发, 2009, 30(1): 41-44.

Gao H, Zheng Z Q, Zhao Z, Yin Y J, Song X Q, Yang K. Physicochemical characteristic of Camembert cheese during ripening. Food Research and Development, 2009, 30(1): 41-44. (in Chinese)

[4]Guizani N, Kasapis S, Alattabi Z H, Al-Ruzeiki M H. Microbiological, physicochemical, and biochemical changes during ripening of Camembert cheese made of pasteurized cow’s milk. International Journal of Food Properties, 2002, 5(3): 483-494.

[5]郑志强, 刘雅楠, 王青华, 赵征. 不同成熟期 Camembert 干酪挥发性风味物质的分析. 食品科技, 2008(1): 88-92.

Zheng Z Q, Liu Y N, Wang Q H, Zhao Z. Analysis of the volatiles in Camembert cheese of different ripening. Food Science and Technology, 2008(1): 88-92. (in Chinese)

[6]Voigt D D, Patterson M F, Linton M, Kelly A L. Effect of high-pressure treatment of milk prior to manufacture on ripening of Camembert cheese. Innovative Food Science & Emerging Technologies, 2011, 12(1): 1-5.

[7]Leclercq-Perlat M N, Sicard M, Trelea I C, Picque D, Corrieu G. Temperature and relative humidity influence the microbial and physicochemical characteristics of Camembert-type cheese ripening. Journal of Dairy Science, 2012, 95(8): 4666-4682.

[8]O'Sullivan N A, Sousa M J, O'Grady-Walsh D, Uniacke T, Kelly A L, McSweeney P L H. Ripening of Camembert-type cheese made from caprine milk using calf rennet or kid rennet as coagulant. International Journal of Dairy Technology, 2005, 58(1): 13-18.

[9]Leclercq-Perlat M N, Buono F, Lambert D, Latrille E, Spinnler H, Corrieu G. Controlled production of Camembert-type cheeses. Part I: Microbiological and physicochemical evolutions. Journal of Dairy Research, 2004, 71(3): 346-354.

[10]Leclercq-Perlat M N, Latrille E, Corrieu G, Spinnler H. Controlled production of Camembert-type cheeses. Part II. Changes in the concentration of the more volatile compounds. Journal of Dairy Research, 2004, 71(3): 355-366.

[11]Schlesser J, Schmidt S, Speckman R. Characterization of chemical and physical changes in Camembert cheese during ripening. Journal of Dairy Science, 1992, 75(7): 1753-1760.

[12]Karami M, Ehsani M R, Mousavi S M, Rezaei K, Safari M. Changes in the rheological properties of Iranian UF-Feta cheese during ripening. Food Chemistry, 2009, 112(3): 539-544.

[13]Hassan A, Awad S, Muthukumarappan K. Effects of exopolysaccharide-producing cultures on the viscoelastic properties of reduced-fat Cheddar cheese. Journal of Dairy Science, 2005, 88(12): 4221-4227.

[14]Liu H, Xu X M, Guo S D. Rheological and textural properties of full-fat and low-fat cheese analogues. Transactions of the CSAE, 2007, 23(5): 32-41.

[15]Lucey J A, Johnson M E, Horne D S. Invited review: perspectives on the basis of the rheology and texture properties of cheese. Journal of Dairy Science, 2003, 86(9): 2725-2743.

[16]Ustunol Z, Kawachi K, Steffe J. Rheological properties of Cheddar cheese as influenced by fat reduction and ripening time. Journal of Food Science, 1995, 60(6): 1208-1210.

[17]Sousa M J, Ardö Y, McSweeney P L H. Advances in the study of proteolysis during cheese ripening. International Dairy Journal, 2001, 11(4): 327-345.

[18]Bergamini C V, Hynes E R, Zalazar C A. Influence of probiotic bacteria on the proteolysis profile of a semi-hard cheese. International Dairy Journal, 2006, 16(8): 856-866.

[19]郑远荣, 刘振民, 莫蓓红, 高红艳, 孙克杰. 切达奶酪成熟过程中微观结构变化及其对质构的影响. 中国农业科学, 2012, 45(3): 503-508.

Zheng Y R, Liu Z M, Mo B H, Gao H Y, Sun K J. Effects of microstructure change on the texture of Cheddar cheese during ripening. Scientia Agricultura Sinica, 2012, 45(3): 503-508. (in Chinese)

[20]屠康, 赵艺泽, 洪莹, 潘磊庆. 利用质构仪对不同类型干酪质地品质的研究. 中国乳品工业, 2004(12): 16-18.

Tu K, Zhao Y Z, Hong Y, Pan L Q. Evaluation of properties of different cheeses with texture profile analysis. China Dairy Industry, 2004(12): 16-18. (in Chinese)

[21]Lobato-Calleros C, Sosa-Pérez A, Rodríguez-Tafoya J, Sandoval- Castilla O, Pérez-Aloso C, Vernon-Carter E J. Structural and textural characteristics of reduced-fat cheese-like products made from W1/O/W2 emulsions and skim milk. LWT-Food Science and Technology, 2008, 41(10): 1847-1856.

[22]Rosenberg M, Wang Z, Chuang S L, Shoemaker C F. Viscoelastic property changes in cheddar cheese during ripening. Journal of Food Science, 1995, 60(3): 640-644.

[23]Spinnler H E, Gripon J C. Surface mould-ripened cheeses // Fox P F, McSweeney P L H, Cogan T M, Guinee T P. Cheese: Chemistry, Physics and Microbiology. 3rd ed. volume 2. Major Cheese Groups. San Diego, California, USA: Elsevier Academic Press, 2004.

[24]Rogers N R, McMahon D J, Daubert C R, Berry T K, Foegeding E A. Rheological properties and microstructure of Cheddar cheese made with different fat contents. Journal of Dairy Science, 2010, 93(10): 4565-4576.

[25]Yang X, Rogers N R, Berry T K, Foegeding E A. Modeling the rheological properties of cheddar cheese with different fat contents at various temperatures. Journal of Texture Studies, 2011, 42(5): 331-348.

Camembert干酪成熟过程中的质构和流变学特性

Texture and Rheological Properties of Camembert Cheeses During Ripening

PDF

赞

可视化

被引次数

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 15

Metrics

本文评价

推荐阅读 0

[1]	董复成,马淑丽,时娟娟,张俊梅,崔岩,任有蛇,张春香. LCN5蛋白在雄性绵羊生殖器官及精子中的表达定位[J]. 中国农业科学, 2022, 55(7): 1445-1457.
[2]	黄兆福, 李璐璐, 侯梁宇, 高尚, 明博, 谢瑞芝, 侯鹏, 王克如, 薛军, 李少昆. 不同种植区玉米生理成熟后田间站秆脱水的积温需求[J]. 中国农业科学, 2022, 55(4): 680-691.
[3]	李文丽, 袁剑龙, 段惠敏, 蒋彤晖, 刘玲玲, 张峰. 马铃薯块茎质地品质的综合评价[J]. 中国农业科学, 2022, 55(12): 2278-2293.
[4]	李昂,苗玉乐,孟君仁,牛良,潘磊,鲁振华,崔国朝,王志强,曾文芳. 溶质和硬质型桃果实成熟过程果肉多肽组学分析[J]. 中国农业科学, 2022, 55(11): 2202-2213.
[5]	陈慧芳,黄绮亮,胡智超,潘晓婷,吴志胜,白银山. 外泌体microRNA在猪成熟和闭锁卵泡中的表达差异及功能分析[J]. 中国农业科学, 2021, 54(21): 4664-4676.
[6]	聂军军,代建龙,杜明伟,张艳军,田晓莉,李召虎,董合忠. 我国现代植棉理论与技术的新发展——棉花集中成熟栽培[J]. 中国农业科学, 2021, 54(20): 4286-4298.
[7]	郭志雄,孙冷雪,郑嘉敏,蔡灿军,王蓓,李开拓,潘腾飞,佘文琴,陈桂信,潘东明. 荔枝果皮BPox的分离纯化及其在果实成熟过程中的表达[J]. 中国农业科学, 2021, 54(16): 3502-3513.
[8]	庄昕波,陈银基,周光宏. 改性甘蔗膳食纤维对猪肉肌原纤维蛋白凝胶特性的影响[J]. 中国农业科学, 2021, 54(15): 3320-3330.
[9]	王旭,张德权,赵莹鑫,摆玉蔷,李欣,侯成立,郑晓春,陈丽. 干法成熟过程羊腿肉持水能力与水分迁移规律[J]. 中国农业科学, 2021, 54(1): 179-189.
[10]	李雪茹,师希雄,王建忠,张攀高,田铸,韩玲. 一氧化氮合成酶抑制剂对宰后成熟过程中牦牛肉品质的影响[J]. 中国农业科学, 2020, 53(8): 1617-1626.
[11]	李培源,李晓飞,李安琪,余文艳,郭绰,杨曦,郭玉蓉. 热碱致魔芋胶与黄原胶共混凝胶的显微结构与流变规律[J]. 中国农业科学, 2020, 53(18): 3792-3804.
[12]	李晓飞,李培源,李安琪,余文艳,郭绰,杨曦,郭玉蓉. 黄原胶添加对碱法诱导魔芋胶凝胶特性及凝胶机制的影响[J]. 中国农业科学, 2020, 53(14): 2941-2955.
[13]	李玲,徐舒,曹如霞,陈玲玲,崔鹏,吕尊富,陆国权. 基于PCA-Entropy TOPSIS的甘薯品种块根质构品质评价[J]. 中国农业科学, 2020, 53(11): 2161-2170.
[14]	史芳芳, 张清安. 超声耦合不同酸度柠檬酸脱苦溶液对苦杏仁品质特性的影响[J]. 中国农业科学, 2019, 52(17): 3034-3048.
[15]	卢丹,赵武奇,曾祥媛,吴妮,高贵田,张清安,张宝善,雷玉山. ‘海沃德’猕猴桃应力松弛特性与品质关系[J]. 中国农业科学, 2019, 52(14): 2548-2558.