|
|
|
|
|
| In-depth observations of fermentative hydrogen production from liquid swine manure using an anaerobic sequencing batch reactor |
| Xiao Wu1, Jun Zhu2, Hongjian Lin3 |
1 Southern Research and Outreach Center, University of Minnesota, MN 56093, USA
2 Biological and Agricultural Engineering Department, University of Arkansas, AR 72701, USA
3 Department of Bioproducts and Biosystems Engineering, University of Minnesota, MN 55108, USA |
|
|
|
|
Abstract In this study, experiments were designed to reveal in-depth information of the effect of pH and hydraulic retention time (HRT) on biohydrogen fermentation from liquid swine manure supplemented with glucose using an Anaerobic Sequencing Batch Reactor (ASBR) System. Five values of HRT (8, 12, 16, 20, and 24 h) were first tested and the best HRT determined was further studied at five pH levels (4.4, 4.7, 5.0, 5.3, and 5.6). The results showed that for HRT 24 h, there was a dividing H2 content (around 37%) related to the total biogas production rate for the ASBR System running at pH 5.0. When the H2 content went beyond 37%, an appreciable decline in biogas production rate was observed, implying that there might exist an H2 content limit in the biogas. For other HRTs (8 through 20 h), an average H2 content of 42% could be achieved. In the second experiment (HRT 12 h), the highest H2 content (35%) in the biogas was found to be associated with pH 5.0. The upswing of pH from 5.0 to 5.6 had a significantly more impact on biogas H2 content than the downswing of pH from 5.0 to 4.3. The results also indicated good linear relationships of biogas and H2 production rates with HRT (r=0.9971 and 0.9967, respectively). Since the optimal ASBR operating conditions were different for the biogas/H2 production rates and the H2 yield, a compromised combination of the running parameters was determined to be HRT 12 h and pH 5.0 in order to achieve good biogas/H2 productions.
|
|
Received: 04 March 2015
Accepted:
|
|
Corresponding Authors:
Jun Zhu, E-mail: junzhu@uark.edu
|
| About author: Xiao Wu, E-mail: wuxxx199@umn.edu |
Cite this article:
Xiao Wu, Jun Zhu, Hongjian Lin.
2017.
In-depth observations of fermentative hydrogen production from liquid swine manure using an anaerobic sequencing batch reactor. Journal of Integrative Agriculture, 16(06): 1276-1285.
|
| Antonopoulou G, Stamatelatou K, Venetsaneas N, Kornaros M, Lyberatos G. 2008. Biohydrogen and methane production from cheese whey in a two-stage anaerobic process. Industrial & Engineering Chemistry Research, 47, 5227–5233.APHA (American Public Health Association). 1998. Standard Methods for the Examination of Water and Wastewater. American Public Health Association, Washington, D.C.Argun H, Kargi F, Kapdan I K, Oztekin R. 2008. Batch dark fermentation of powdered wheat starch to hydrogen gas: Effects of the initial substrate and biomass concentrations. International Journal of Hydrogen Energy, 33, 6109–6115.Benemann J. 1996. Hydrogen biotechnology: Progess and prospects. Nature Biotechnology, 14, 1101–1103.Bi?áková O, Straka P. 2012. Production of hydrogen from renewable resources and its effectiveness. International Journal of Hydrogen Energy, 37, 11563–11578.del Campo A G, Cañizares P, Lobato J, Rodrigo M A, Fernandez F J. 2012. Electricity production by integration of acidogenic fermentation of fruit juice wastewater and fuel cells. International Journal of Hydrogen Energy, 37, 9028–9037.del Campo A G, Fernández F J, Cañizares P, Rodrigo M A, Pinar F J, Lobato J. 2014. Energy recovery of biogas from juice wastewater through a short high temperature PEMFC stack. International Journal of Hydrogen Energy, 39, 6937–6943.Chang F Y, Lin C Y. 2004. Biohydrogen production using an up-flow anaerobic sludge blanket reactor. International Journal of Hydrogen Energy, 29, 33–39.Chang J S, Lee K S, Lin P J. 2002. Biohydrogen production with fixed-bed bioreactors. International Journal of Hydrogen Energy, 27, 1167–1174.Chen S D, Lee K S, Lo Y C, Chen W M, Wu J F, Lin C Y, Chang J S. 2008. Batch and continuous biohydrogen production from starch hydrolysate by Clostridium species. International Journal of Hydrogen Energy, 33, 1803–1812.Das D, Veziroglu T N. 2001. Hydrogen production by biological processes: A survey of literature. International Journal of Hydrogen Energy, 26, 13–28.Dunn S. 2002. Hydrogen futures: Toward s sustainable energy system. International Journal of Hydrogen Energy, 27, 235–264.Fang H H P, Li C L, Zhang T. 2006. Acidophilic biohydrogen production from rice slurry. International Journal of Hydrogen Energy, 31, 683–692.Fernández F J, Villaseñor J, Infantes D. 2011. Kinetic and stoichiometric modelling of acidogenic fermentation of glucose and fructose. Biomass and Bioenergy, 35, 3877–3883.Gadhe A, Sonawane S S, Varma M N. 2013. Optimization of conditions for hydrogen production from complex dairy wastewater by anaerobic sludge using desirability function approach. International Journal of Hydrogen Energy, 38, 6607–6617.García-Peña E I, Guerrero-Barajas C, Ramirez D, Arriaga-Hurtado L G. 2009. Semi-continuous biohydrogen production as an approach to generate electricity. Bioresource Technology, 100, 6369–6377.Van Ginkel S W, Logan B. 2005. Increased biological hydrogen production with reduced organic loading. Water Research, 39, 3819–3826.Han W, Wang B, Zhou Y, Wang D X, Wang Y, Yue LV R, Li Y F, Ren N Q. 2012. Fermentative hydrogen production from molasses wastewater in a continuous mixed immobilized sludge reactor. Bioresource Technology, 110, 219–223.Infantes D, del Campo A G, Villaseñor J, Fernández F J. 2011. Influence of pH, temperature and volatile fatty acids on hydrogen production by acidogenic fermentation. International Journal of Hydrogen Energy, 36, 15595–15601.Jin Q. 2007. Control of hydrogen partial pressures on the rates of syntrophic microbial metabolisms: A kinetic model for butyrate fermentation. Geobiology, 5, 35–48.Jung K W, Kim D H, Kim S H, Shin H S. 2011. Bioreactor design for continuous dark fermentative hydrogen production. Bioresource Technology, 102, 8612–8620.Kaparaju P, Ellegaard L, Angelidaki I. 2009. Optimisation of biogas production from manure through serial digestion: Lab-scale and pilot-scale studies. Bioresource Technology, 100, 701–709.Kargi F, Uzunçar S. 2012. Simultaneous hydrogen gas formation and COD removal from cheese whey wastewater by electrohydrolysis. International Journal of Hydrogen Energy, 37, 11656–11665.Kim S H, Han S K, Shin H S. 2005. Performance comparison of a continuous-flow stirred-tank reactor and an anaerobic sequencing batch reactor for fermentative hydrogen production depending an substrate concentration. Water Science and Technology, 52, 23–29.Lay J J. 2001. Biohydrogen generation by mesophilic anaerobic fermentation of microcrystalline cellulose. Biotechnology and Bioengineering, 74, 280–287.Lay J J, Tsai C J, Huang C C, Chang J J, Chou C H, Fan K S, Chang J I, Hsu P C. 2005. Influences of pH and hydraulic retention time on anaerobes converting beer processing wastes into hydrogen. Water Science and Technology, 52, 123–129.Lee K S, Lin P J, Chang J S. 2006. Temperature effects on biohydrogen production in a granular sludge bed induced by activated carbon carriers. International Journal of Hydrogen Energy, 31, 465–472.Lee K S, Wu J F, Lo Y S, Lo Y C, Lin P J, Chang J S. 2004. Anaerobic hydrogen production with an efficient carrier-induced granular sludge bed bioreactor. Biotechnology and Bioengineering, 87, 648–657.Liu Z, Zhang C, Lu Y, Wu X, Wang L, Wang L, Han B, Xing X H. 2013. States and challenges for high-value biohythane production from waste biomass by dark fermentation technology. Bioresource Technology, 135, 292–303.Mandal B, Nath K, Das D. 2006. Improvement of biohydrogen production under decreased partial pressure of H2 by Enterobacter cloacae. Biotechnology Letters, 28, 831–835.Mann R F, Amphlett J C, Hooper M A I, Jensen H M, Peppley B A, Roberge P R. 2000. Development and application of a generalised steady-state electrochemical model for a PEM fuel cell. Journal of Power Sources, 86, 173–180.Mu Y, Yu H Q, Wang Y. 2006. The role of pH in the fermentative H2 production from an acidogenic granule-based reactor. Chemosphere, 64, 350–358.Park M J, Jo J H, Park D, Lee D S, Park J M. 2010. Comprehensive study on a two-stage anaerobic digestion process for the sequential production of hydrogen and methane from cost-effective molasses. International Journal of Hydrogen Energy, 35, 6194–6202.Pattra S, Lay C H, Lin C Y,O-Thong S, Reungsang A. 2011. Performance and population analysis of hydrogen production from sugarcane juice by non-sterile continuous stirred tank reactor augmented with Clostridium butyricum. International Journal of Hydrogen Energy, 36, 8697–8703.Pender S, Toomey M, Carton M, Eardly D, Patching J W, Colleran E, O’Flaherty V. 2004. Long-term effects of operating temperature and sulphate addition on the methanogenic community structure of anaerobic hybrid reactors. Water Research, 38, 619–630.Rai P K, Singh S P, Asthana R K, Singh S. 2014. Biohydrogen production from sugarcane bagasse by integrating dark- and photo-fermentation. Bioresource Technology, 152, 140–146.Tawfik A, El-Qelish M. 2012. Continuous hydrogen production from co-digestion of municipal food waste and kitchen wastewater in mesophilic anaerobic baffled reactor. Bioresource Technology, 114, 270–274.Ting C H, Lee D J. 2007. Production of hydrogen and methane from wastewater sludge using anaerobic fermentation. International Journal of Hydrogen Energy, 32, 677–682.Ueno Y, Haruta S, Ishii M, Igarashi Y. 2001. Characterization of a microorganism isolated from the effluent of hydrogen fermentation by microflora. Journal of Bioscience and Bioengineering, 92, 397–400.Wang C H, Chang J S. 2008. Continuous biohydrogen production from starch with granulated mixed bacterial microflora. Energy & Fuels, 22, 93–97.Wang C H, Lin P J, Chang J S. 2006. Fermentative conversion of sucrose and pineapple waste into hydrogen gas in phosphate-buffered culture seeded with municipal sewage sludge. Process Biochemistry, 41, 1353–1358.Won S G, Baldwin S A, Lau A K, Rezadehbashi M. 2013. Optimal operational conditions for biohydrogen production from sugar refinery wastewater in an ASBR. International Journal of Hydrogen Energy, 38, 13895–13906.Wu X, Zhu J, Dong C Y, Miller C, Li Y C, Wang L, Yao W Y. 2009. Continuous biohydrogen production from liquid swine manure supplemented with glucose using an anaerobic sequencing batch reactor. International Journal of Hydrogen Energy, 34, 6636–6645.Yang P F, Zhang R H, MeGarvey J A, Benernann J R. 2007. Biohydrogen production from cheese processing wastewater by anaerobic fermentation using mixed microbial communities. International Journal of Hydrogen Energy, 32, 4761–4771.Yokoi H, Maki R, Hirose J, Hayashi S. 2002. Microbial production of hydrogen from starch-manufacturing wastes. Biomass & Bioenergy, 22, 389–395.Yokoi H, Saitsu A, Uchida H, Hirose J, Hayashi S, Takasaki Y. 2001. Microbial hydrogen production from sweet potato starch residue. Journal of Bioscience and Bioengineering, 91, 58–63.Yu H Q, Zhu Z H, Hu W R, Zhang H S. 2002. Hydrogen production from rice winery wastewater in an upflow anaerobic reactor by using mixed anaerobic cultures. International Journal of Hydrogen Energy, 27, 1359–1365.Zhang Z P, Show K Y, Tay J H, Liang D T, Lee D J. 2008. Biohydrogen production with anaerobic fluidized bed reactors - A comparison of biofilm-based and granule-based systems. International Journal of Hydrogen Energy, 33, 1559–1564.Zhao L, Cao G L, Wang A J, Ren H Y, Ren N Q. 2013. Evaluation of continuous biohydrogen production from enzymatically treated cornstalk hydrolysate. International Journal of Hydrogen Energy, 38, 15100–15104.Zhu H G, Ueda S, Asada Y, Miyake J. 2002. Hydrogen production as a novel process of wastewater treatment - Studies on tofu wastewater with entrapped R-sphaeroides and mutagenesis. International Journal of Hydrogen Energy, 27, 1349–1357.Zhu J, Li Y C, Wu X, Miller C, Chen P, Ruan R. 2009. Swine manure fermentation for hydrogen production. Bioresource Technology, 100, 5472–5477.Zhu J, Wu X, Miller C, Yu F, Chen P, Ruan R. 2007. Biohydrogen production through fermentation using liquid swine manure as substrate. Journal of Environmental Science and Health (Part B - Pesticides Food Contaminants and Agricultural Wastes), 42, 393–401. |
| No Suggested Reading articles found! |
|
|
Viewed |
|
|
|
Full text
|
|
|
|
|
Abstract
|
|
|
|
|
Cited |
|
|
|
|
| |
Shared |
|
|
|
|
| |
Discussed |
|
|
|
|
