16个苹果品种非浓缩还原汁的理化特征分析

doi:10.3864/j.issn.0578-1752.2018.04.019

摘要/Abstract

摘要： 【目的】通过研究16种苹果非浓缩还原汁（not from concentrate，NFC）果汁的8项理化指标，利用相关性分析明确指标间的关系，以简化NFC果汁品质的评价指标。此外，利用多元数据处理对不同品种苹果NFC果汁进行归类，以找到NFC果汁生产中制汁和智能复配的替代品种，为NFC果汁产业发展提供理论参考。【方法】以16个苹果品种为试材，经榨汁、灭酶、巴杀、热灌装等单元操作制备NFC果汁。通过测定16种果汁的可溶性固形物含量、pH、可滴定酸含量、固酸比、表观黏度、浊度、总酚含量及色泽品质（L^*、a^*、b^*、C^*、h°）指标，采用单因素方差分析与相关性分析对测定结果进行显著性和相关性分析。此外，利用主成分分析（PCA）、线性判别分析（LDA）、聚类分析（CA）多元数据处理方法，对16种果汁的理化指标数据矩阵进行分析，获得16个苹果品种的综合品质分类。【结果】16种苹果汁的各项理化指标均存在显著差异，其中，‘新世界’的可溶性固形物含量和浊度最高，分别为15.7 °Brix和3 720 NTU；‘澳洲青苹’的pH最低，为2.74；‘红玉’的可滴定酸含量最高，为9.6 g·L^-1（苹果酸当量）；‘秦艳’的固酸比最高，为39.24；‘元帅’‘恩派’‘桔苹’都表现出最高的表观黏度，均为3.75 mPa·s；‘富士’的总酚含量最高，为775.94 mg·L^-1（没食子酸当量）。果汁pH与固酸比（R²=0.844）、浊度与L^*值（R²=0.967）均呈极显著正相关关系（P<0.01），pH与可滴定酸含量（R²=-0.896）、固酸比与可滴定酸含量（R²=-0.918）均呈极显著负相关关系（P<0.01）。PCA、LDA和CA的分类结果完全一致，16个品种的NFC苹果汁可分为3大类，同一大类中各品种之间不同理化指标差异较小，品质、色泽十分接近，可作为NFC果汁生产和智能复配的可替代品种。【结论】可溶性固形物含量、可滴定酸含量、色值、表观黏度、总酚含量5项理化指标，可全面反映NFC果汁的品质。在果汁品质分类中，‘玉华早富’和‘乔纳金’归为一类，‘新世界’和‘秦冠’归为一类，‘新红星’‘富士’‘桔苹’‘自由’‘秦艳’‘澳洲青苹’、‘秋香’‘粉红女士’‘元帅’‘恩派’‘凉香’‘红玉’归为一类，同一类别中NFC果汁品质接近，可作为制汁和智能复配的替代品种。

关键词: 苹果非还原汁, 品质分析, 归类, 加工替代品种

Abstract: 【Objective】The eight physicochemical properties of the not from concentrate (NFC) apple juices from sixteen cultivars were investigated in this study. Correlation analysis of all measured variables was applied for simplifying the evaluating indicators of NFC apple juices. Moreover, multivariate data analyses were applied to categorize apple juices, in hope of finding out the alternative cultivars in NFC juice production and intelligent formulation, and thus providing theoretical basis for juice industry.【Method】NFC juices from sixteen cultivars were prepared through squeezing, inactivating enzymes, pasteurization and hot filling. Eight physicochemical properties of sixteen juices, including the total soluble solids (TSS) content, pH value, titratable acidity (TA), TSS/TA, apparent viscosity, turbidity, total phenol content (TPC) and color quality (L^*, a, b, C, ^*h°) were determined, and their differences and correlations of the properties were evaluated using variance analysis and correlation analysis methods, respectively. Additionally, principal component analysis (PCA), liner discriminant analysis (LDA) and cluster analysis (CA) were applied to analyze the data matrix of physicochemical properties to classify sixteen juices.【Result】 The results showed that physicochemical properties of sixteen juices were significantly different. The cultivar ‘Xinshijie’ had the highest TSS content (15.7 °Brix) and turbidity (3 720 NTU), while ‘Granny Smith’ possessed the lowest pH (2.74), ‘Jonathan’ possessed the highest TA value (9.6 g·L^-1, malic acid equivalent), and ‘Qinyan’ had the highest TSS/TA (39.24). Besides, three cultivars ‘Delicious’, ‘Empire’ and ‘Cox’s orange pippin’ showed the highest apparent viscosity (3.75 mPa·s), and ‘Fuji’ possessed the highest TPC (775.94 mg·L^-1, gallic acid equivalent). pH value and TSS/TA were extremely significantly positive correlation (R²=0.844), and turbidity and L^* value also showed extremely positive correlation (R²=0.967, P<0.01). However, pH and TA (R²=-0.896), as well as TSS/TA and TA (R²=-0.918) showed extremely negative correlation (P<0.01). The results from PCA, LDA and CA provided the totally same classification, and the sixteen cultivars were classified into three categories.【Conclusion】The original eight physicochemical properties could be simplified to five indicators, they are TSS, TA, color quality (L^*, a^*, b^*, C^*, h°), apparent viscosity and TPC. These five indicators can be used to reflect overall the quality of NFC apple juices. Based on the classification of juice quality, the cultivar ‘Yuhuazaofu’ and ‘Jonagold’ formed the first group, ‘Xinshijie’ and ‘Qinguan’ constituted the second group, and ‘Starkrimson’, ‘Fuji’, ‘Cox’s orange pippin’, ‘Ziyou’, ‘Qinyan’, ‘Granny Smith’, ‘Qiuxiang’, ‘Pink lady’, ‘Delicious’, ‘Empire’, ‘Liangxiang’, ‘Jonathan’ formed the third group. The cultivars in the same group can be the alternatives in NFC juice production and intelligent formulation.

Key words: apple juice not from concentrate (NFC), quality analysis, classification, alternative varieties

苟小菊，田由，郭玉蓉，杨曦，侯燕杰. 16个苹果品种非浓缩还原汁的理化特征分析[J]. 中国农业科学, 2018, 51(4): 800-810.

GOU XiaoJu, TIAN You, GUO YuRong, YANG Xi, HOU YanJie. Analyses of Physicochemical Properties of NFC Apple Juices from Sixteen Cultivars[J]. Scientia Agricultura Sinica, 2018, 51(4): 800-810.

0
/ / 推荐

导出引用管理器 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

链接本文: https://www.chinaagrisci.com/CN/10.3864/j.issn.0578-1752.2018.04.019

https://www.chinaagrisci.com/CN/Y2018/V51/I4/800

参考文献

[1] 王旭芳. 提升产业价值链打造中国“苹果梦”. 中国农村科技, 2016(8): 28-35.

WANG X F. Improvement of industry value chain to build the "apple dream" of China. China Rural Science and Technology, 2016(8): 28-35. (in Chinese)

[2] 纪杨洋, 王丽萍. 苹果加工研究进展. 保鲜与加工, 2017(1): 126-129.

JI Y Y, WANG L P. Research progress on apple processing. Storage and Process, 2017(1): 126-129. (in Chinese)

[3] 刘军弟, 王静, 刘天军, 韩明玉, 霍学喜. 中国苹果加工产业发展趋势分析. 林业经济问题, 2012, 32(2): 185-188.

LIU J D, WANG J, LIU T J, HAN M Y, HUO X X. Trend for development of apple processing industry in China. Issues of Forestry Economics, 2012, 32(2): 185-188. (in Chinese)

[4] KATO K, SHIMOD M, SUZUKI J. Changes in the odor of squeezed apple juice during thermal processing. Food Research International, 2003, 36: 777-785.

[5] JOHNSON J R, BRADDOCK J, CHEN C S. Flavor losses in orange juice during ultrafiltration and subsequent evaporation. Journal of Food Science, 2006, 21(3): 540-543.

[6] CHOU F, WILEYR C, SCHLIMME D V. Reverse osmosis and flavor retention in apple juice concentration. Journal of Food Science, 2006, 56(2): 484-487.

[7] LILIANA C N, JORGEL E. Use of enzymes for non-citrus fruit juice production//Enzymes in Fruit and Vegetable Processing. Turkey: CRC Press, 2010: 175-195.

[8] LLORENTE D D, ABRODO P A, FUENTE E D. Experimental design applied to the analysis of volatile compounds in apple juice by headspace solid-phase micro-extraction. Journal of Separation Science, 2011, 34(11): 1293-1298.

[9] NIKFARDJAM M P, MAIER D. Development of a headspace trap

HRGC/MS method for the assessment of the relevance of certain aroma compounds on the sensorial characteristics of commercial apple juice. Food Chemistry, 2011, 126(4): 1926-1933.

[10] 聂继云, 李志霞, 李海飞, 李静, 王昆，毋永龙. 苹果理化品质评价指标研究. 中国农业科学, 2012, 45(14): 2895-2903.

NIE J Y, LI Z X, LI H F, LI J, WANG K, WU Y L. Evaluation indices for apple physicochemical quality. Scientia Agricultura Sinica, 2012, 45(14): 2895-2903. (in Chinese)

[11] 聂继云. 果品质量安全分析技术. 北京: 化学工业出版社, 2009.

NIE J Y. The Analysis Technology of Fruit Quality and Safety. Beijing: Chemical Industry Press, 2009. (in Chinese)

[12] BIRSE M. The colour of red wine [D]. Adelaide: The University of Adelaide, 2007.

[13] 王白鸥. 果汁中的多酚物质及测定. 中国果菜, 2001(5): 27.

WANG B O. The polyphenols and determination of fruit juice. China Fruit Vegetable, 2001(5): 27. (in Chinese)

[14] 樊书祥, 黄文倩, 郭志明, 张保华, 赵春江, 钱曼. 苹果产地差异对可溶性固形物近红外影响的研究. 分析化学, 2015(2): 239-244.

FAN S X, HUANG W Q, GUO Z M, ZHANG B H, ZHAO C J, QIAN M. Assessment of influence of origin variability on robustness of Near Infrared Models for soluble solid content of apples. Chinese Journal of Analytical Chemistry, 2015(2): 239-244. (in Chinese)

[15] 贾定贤, 米文广, 杨儒琳, 陈素芬, 张凤兰. 苹果品种果实糖、酸含量的分级标准与风味的关系. 园艺学报, 1991, 18(1): 9-14.

JIA D X, MI W G, YANG R L, CHEN S F, ZHANG F L. Sugar and acid content of fruit and its classification standard associated with flavor in different apple cultivars. Acta Horticulturae Sinica, 1991, 18(1): 9-14. (in Chinese)

[16] 何进武, 梁敏思, 樊伟伟, 黄惠华. 澄清苹果汁的流变特性研究. 食品工业科技, 2008, 29(3): 133-135.

HE J W, LIANG M S, FAN W W, HUANG H H. Study on rheological behavior of clarified apple juices. Science and Technology of Food Industry, 2008, 29(3):133-135. (in Chinese)

[17] ILAN S, TATIANA Y, UZI M. Involvement of proteins in cloud instability of shamouti orange juice. Journal of Agriculture and Food Chemistry, 1999, 47: 2623-2631.

[18] 徐颖, 樊明涛, 冉军舰, 程拯艮，戚一曼. 不同品种苹果籽总酚含量与抗氧化相关性研究. 食品科学, 2015, 36(1): 79-83.

XU Y, FAN M T, RAN J J, CHENG Z L, QI Y M. Correlation between total phenolic content and antioxidant activity in apple seeds from seven cultivars. Food Science, 2015, 36(1): 79-83. (in Chinese)

[19] 郑倩, 张燕, 廖小军, 陈芳, 李淑燕, 胡小松. 超高压对果蔬颜色品质影响的研究进展. 食品与发酵工业, 2010(5): 105-109.

ZHENG Q, ZHANG Y, LIAO X J, CHEN F, LI S Y, HU X S. Progress in research of high pressure processing on color quality of fruit and vegetable. Food and Fermentation Industries, 2010(5): 105-109. (in Chinese)

[20] 王晓慧. 线性判别分析与主成分分析及其相关研究评述. 中山大学研究生学刊(自然科学、医学版), 2007(4): 50-61.

WANG X H. A summary of LDA, PCA and relative work. Journal of the Graduates Sun Yat-Sen University (Natural Sciences, Medicine), 2007(4): 50-61. (in Chinese)

[21] MAVROUDIS N E, DEJMEK P, SJÖHOLM I. Studies on some raw material characteristics in different Swedish apple varieties. Journal of Food Engineering, 2004, 62(2): 121-129.

[22] 阎振立, 张恒涛, 过国南, 刘珍珍. 早中熟苹果的生产状况与发展建议. 果农之友, 2010(12): 5-7.

YAN Z L, ZHANG H T, GUO G N, LIU Z Z. In the early ripe apple production status and development suggestions. Fruit Growers’ Friend, 2010(12): 5-7. (in Chinese)

[23] 聂继云, 毋永龙, 李海飞, 王昆, 李静, 李志霞, 徐国锋. 苹果品种用于加工鲜榨汁的适宜性评价. 农业工程学报, 2013, 29(17): 271-278.

NIE J Y, WU Y L, LI H F, WANG K, LI J, LI Z X, XU G F. Suitability evaluation of apple cultivars for fresh juice-processing. Transactions of the Chinese Society of Agricultural Engineering, 2013, 29(17): 271-278. (in Chinese)

[24] 何维华, 周亚平, 曲凌慧, 刘春辉, 于士梅, 祝军, 戴洪义. 苹果汁色泽相关性状的遗传. 果树学报, 2008, 25(2): 157-161.

HE W H, ZHOU Y P, QU L H, LIU C H, YU S M, ZHU J, DAI H Y. Study on the inheritance of color characteristics of apple juice. Journal of Fruit Science, 2008, 25(2): 157-161. (in Chinese)

[25] 邓健康, 毕金峰, 刘璇, 钟耀广, 王萍. 苹果汁品质评价方法研究进展. 中国果菜, 2014(2): 56-61.

DENG J K, BI J F, LIU X, ZHONG Y G, WANG P. Research progress in methods of evaluation assessment of apple juice. China Fruit Vegetable, 2014(2): 56-61. (in Chinese)

[26] GUO J, YUE T L, YUAN Y H, WANG Y. Chemometric classification of apple juice according to variety and geographical origin based on polyphenolic profiles. Journal of Agricultural and Food Chemistry, 2013, 61: 6949-6963.

[27] 郑丽静, 聂继云, 李明强, 康艳玲, 匡立学, 叶孟亮. 苹果风味评价指标的筛选研究. 中国农业科学, 2015, 48(14): 2796-2805.

ZHENG L J, NIE J Y, LI M Q, KANG Y L, KUANG L X, YE M L. Study on screening of taste evaluation indexes for apple. Scientia Agricultura Sinica, 2015, 48(14): 2796-2805. (in Chinese)

[28] 刘金豹, 翟衡, 张静. 果汁褐变及其影响因素研究进展. 饮料工业, 2004, 7(3): 1-5.

LIU J B, ZHAI H, ZHANG J. Progress in research on juice browning and factors influencing it. Beverage Industry, 2004, 7(3): 1-5. (in Chinese)

[29] 李秀芳, 饶景萍, 马秋诗, 孙振营, 韩叶. 红富士苹果采后1-MCP处理对果皮色素及其相关酶活性的影响. 园艺学报, 2014, 41(3): 447-455.

LI X F, RAO J P, MA Q S, SUN Z Y, HAN Y. Effects of 1-MCP treatment on the pericarp pigment and the activity of related enzymes of ‘Red Fuji’ apple. Acta Horticulturae Sinica, 2014, 41(3): 447-455. (in Chinese)

[30] 林海明, 杜子芳. 主成分分析综合评价应该注意的问题. 统计研究, 2013, 30(8): 25-31.

LIN H M, DU Z F. Some problems in comprehensive evaluation in the principal component analysis. Statistical Research, 2013, 30(8): 25-31. (in Chinese)

[31] 李道红. 线性判别分析新方法研究及其应用[D]. 南京: 南京航空航天大学, 2005.

LI D H. Research on new methods of linear discriminant analysis and their applications [D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2005. (in Chinese)

[32] 公丽艳, 孟宪军, 刘乃侨, 毕金峰. 基于主成分与聚类分析的苹果加工品质评价. 农业工程学报, 2014, 30(13): 276-285.

GONG L Y, MENG X J, LIU N Q, BI J F. Evaluation of apple quality based on principal component and hierarchical cluster analysis. Transactions of the Chinese Society of Agricultural Engineering, 2014, 30(13): 276-285. (in Chinese)