防治蓟马的球孢白僵菌SDDZ-9菌株液体发酵工艺优化

doi:10.3864/j.issn.0578-1752.2015.15.008

摘要/Abstract

摘要： 【目的】球孢白僵菌(Beauveria bassiana)作为一种重要的虫生真菌，已广泛应用于害虫生物防治，但其不成熟的规模化生产技术一直是限制球孢白僵菌广泛应用的主要问题之一。开展球孢白僵菌液体发酵工艺研究，提高液体发酵生物量，从而为固体发酵阶段提供优质的种子液，进而提高固体发酵的产孢量，为球孢白僵菌规模化生产提供参考。【方法】影响球孢白僵菌液体发酵的培养条件有温度、装样量、摇床转速、接种浓度和pH等，首先采用Plackett-Burman试验设计，筛选出影响球孢白僵菌菌株SDDZ-9的液体发酵的主要因子，然后运用最陡爬坡路径法，以试验值变化的梯度方向和各因素效应值的大小分别确定爬坡方向和变化步长，确定响应面的中心点，逼近最佳值区域，最后采用central composite design (CCD)响应曲面法，建立多元二次回归方程来拟合各因素与效应值之间的关系，并对影响发酵生物量的各因素及其交互作用进行响应面分析和评价，确定对西花蓟马(Frankliniella occidentalis)毒力较高的球孢白僵菌菌株SDDZ-9液体发酵的最优培养条件。【结果】培养温度、装样量、转速和浓度是影响发酵生物量的主要因子，一定范围内的pH变化对此菌株的液体发酵影响较小。在自然pH下，当培养温度27.08℃、装样49.72 mL（250 mL三角瓶）、摇床转速205.45 r/min、接种浓度1.122×10⁷孢子/mL时，发酵48 h产生的生物量最大。在优化发酵条件下进行液固双相发酵试验，得到的球孢白僵菌液体发酵生物量为14.769 g·L^-1，与模型预测生物量相符，固体发酵后产孢量为20.16 g·kg^-1，含孢量1.84×10¹¹孢子/g。【结论】在优化发酵工艺条件下进行发酵，可显著提高球孢白僵菌的产孢量，此液体发酵工艺为球孢白僵菌的规模化生产奠定了基础。

关键词: 球孢白僵菌, 响应曲面法, 发酵条件, 优化

Abstract: 【Objective】Entomopathogenic fungus Beauveria bassiana has been widely applied as an important biocontrol agent for controlling many insect pests, while the poorly large-scale production technology of B. bassiana is one of the key issues which may consequently restrict its wide application. Study on the liquid fermentation process research of B. bassiana can improve the liquid fermentation of biomass, thereby providing high-quality fermentation broth for solid liquid fermentation stage and improving spore production of solid fermentation. The study may serve as a basis for the large-scale production technology of B. bassiana. 【Method】The liquid fermentation of B. bassiana is affected by several factors, such as temperature, volume of liquid, rotate speed, initial conidia concentration, pH and so on. Firstly, Plackett-Burman (PB) design was used to screen the main factors which affected the liquid fermentation. Secondly, the method of the steepest ascent path was applied to identify the central point of response surface and approach the optimal region. The climbing direction and the change range were determined by gradient direction of experimental value changes and the effect value of each factor, respectively. Lastly, the central composite design (CCD) was adopted to identify the optimal liquid fermentation concentration by setting up a multiple quadratic regression equation, analyzing and evaluating the correlations among these factors which affect the mycelium mass of B. bassiana SDDZ-9, one of the most virulent strains against western flower thrips (Frankliniella occidentalis. 【Result】Temperature, volume of liquid, rotate speed and initial conidia concentration were the main factors on mycelium mass. The change of pH within certain limits had less influence on this strain of liquid fermentation. Without considering pH, when the fermentation conditions of temperature, volume of liquid, rotate speed and initial concentration were 27.08℃, 49.72 mL/250 mL of triangular flask, 205.45 r/min, and 1.122×10⁷conidia/mL, the maximum mycelium mass was produced after 48 h of fermentation. Using the culture conditions to produce conidia, the mycelium mass obtained was about 14.769 g·L^-1, which was consistent with the predicted biomass. After the solid state fermentation, the yield achieved about 20.16 g·kg^-1 and 1.84×10¹¹conidia/g.【Conclusion】The spore production of B. bassiana could be significantly improved under optimized fermentation conditions. The results may provide reference for large-scale liquid fermentation of B. bassiana SDDZ-9.

Key words: Beauveria bassiana, response surface methodology, fermentation conditions, optimization

张璐璐，吴圣勇，王帅宇，李娟，雷仲仁. 防治蓟马的球孢白僵菌SDDZ-9菌株液体发酵工艺优化[J]. 中国农业科学, 2015, 48(15): 2985-2994.

ZHANG Lu-lu, WU Sheng-yong, WANG Shuai-yu, LI Juan, LEI Zhong-ren. Optimization of Fermentation Process of Beauveria bassiana of SDDZ-9 Against Frankliniella occidentalis[J]. Scientia Agricultura Sinica, 2015, 48(15): 2985-2994.

0
/ / 推荐

导出引用管理器 EndNote|Reference Manager|ProCite|BibTeX|RefWorks

链接本文: https://www.chinaagrisci.com/CN/10.3864/j.issn.0578-1752.2015.15.008

https://www.chinaagrisci.com/CN/Y2015/V48/I15/2985

参考文献

[1] 吴正铠. 杀虫微生物. 第一卷. 北京: 北京农业大学出版社, 1987: 41-46.

Wu Z K. Microbial Insecticide.Vol.1. Beijing: Beijing Agricultural University Press, 1987: 41-46. (in Chinese)

[2] 张丽靖, 冯明光. 基于球孢白僵菌的真菌杀虫剂生产工艺与剂型述评. 浙江农业学报, 2004, 16(6): 395-399.

Zhang L J, Feng M G. A minireview on technology for the production and formulation of Beauveria bassiana-based mycoinsecticides. Acta Agriculturae Zhejiangensis, 2004, 16(6): 395-399. (in Chinese)

[3] Daigle D J, Connick W J, Boyette C D, Jackson M A, Dorner J W. Solid-state fermentation plus extrusion to make biopesticide granules. Biotechnology Techniques, 1998, 12(10): 715-719.

[4] Feng M G, Poprawski T J, Khachatourians G G. Production, formulation and application of the entomopathgenic fungus Beauveria bassiana for insect control: current status. Biocontrol Science and Technology, 1994, 4(1): 3-34.

[5] 朱天辉, 杨世璋, 李远翔. 球孢白僵菌液体制剂研究. 四川农业大学学报, 2001, 19(1): 1-3.

Zhu T H, Yang S Z, Li Y X. The study on a liquid preparation of Beauveria bassiana. Journal of Sichuan Agricultural University, 2001, 19(1): 1-3. (in Chinese)

[6] 周晓妹. 白僵菌液体深层培养的研究[D]. 福州: 福建农林大学, 2007.

Zhou X M. Study on Beauveria bassiana cultivated in submerged culture[D]. Fuzhou: Fujian Agriculture and Forestry University, 2007. (in Chinese)

[7] 张亚平, 吴圣勇, 王海鸿, 雷仲仁. 球孢白僵菌液体生长营养和培养条件优化. 植物保护, 2014, 40(6): 87-93.

Zhang Y P, Wu S Y, Wang H H, Lei Z R. Optimization of submerged culture conditions for blastospore and biomass production of Beaveria bassiana. Plant Protection, 2014, 40(6): 87-93. (in Chinese)

[8] Thomas K C, Khachatourians G G, Ingledew W M. Production and properties of Beauveria bassiana conidia cultivated in submerged culture. Canadian Journal of Microbiology, 1987, 33(1): 12-20.

[9] Pham T A, Kim J J, Kim S G, Kim K. Production of blastospore of entomopathogenic Beauveria bassiana in a submerged batch culture. Mycobiology, 2009, 37(3): 218-224.

[10] 王万中. 试验的设计与分析. 北京: 高等教育出版社, 2004.

Wang W Z. Design and Analysis of Experiments. Beijing: Higher Education Press, 2004. (in Chinese)

[11] 郝琪, 杨林松, 曹立波. 基于响应面法的车身刚度特性的优化设计. 机械科学与技术, 2010, 29(11): 1569-1573.

Hao Q, Yang L S, Cao L B. Optimization of the stiffness of a car body based on response surface method. Mechanical Science and Technology for Aerospace Engineering, 2010, 29(11): 1569-1573. (in Chinese)

[12] 张超, 胡蒋宁, 范亚苇, 李静, 刘蓉, 邓泽元. 响应面法优化酶催化紫苏籽油合成富含α-亚麻酸甘油二酯的工艺条件. 中国农业科学, 2011, 44(5): 1006-1014.

Zhang C, Hu J N, Fan Y W, Li J, Liu R, Deng Z Y. Lipase-catalyzed synthesis of diacylglycerol rich in α-linolenic acid from perilla seed oil by response surface methodology. Scientia Agricultura Sinica, 2011, 44(5): 1006-1014. (in Chinese)

[13] Lai L S T, Pan C C, Tzeng B K. The influence of medium design on lovastatin in production and pellet formation with a high-producing mutant of Aspergillus terreus in submerged cultures. Process Biochemistry, 2003, 38(9): 1317-1326.

[14] 张荣胜, 梁雪杰, 刘永锋, 罗楚平, 王晓宇, 刘邮洲, 乔俊卿, 陈志谊. 解淀粉芽胞杆菌Lx-11生物发酵工艺优化. 中国生物防治学报, 2013, 29(2): 254-262.

Zhang R S, Liang X J, Liu Y F, Luo C P, Wang X Y, Liu Y Z, Qiao J Q, Chen Z Y. Optimization of fermentation process of Bacillus amyloliquefaciens Lx-11. Chinese Journal of Biological Control, 2013, 29(2): 254-262. (in Chinese)

[15] 贺小贤, 潘亚磊. 响应面法优化酿酒酵母YF发酵产谷胱甘肽条件. 食品科技, 2010, 35(10): 15-19.

He X X, Pan Y L. Optimization Saccharomyces cerevisiae YF fermentation conditions for glutathione producing by response surface analysis. Food Science and Technology, 2010, 35(10): 15-19. (in Chinese)

[16] Yuan L L, Li Y Q, Wang Y, Zhang X H, Xu Y Q. Optimization of critical medium components using response surface methodology for phenazine-1-carboxylic acid production by Pseudomonas sp. M-18Q. Journal of Bioscience and Bioengineering, 2008, 105(3): 232-237.

[17] Guo H, Zhang Z Y, Qian J Q, Liu Y. Optimization of the liquid-liquid extraction of phosphatidyl-choline from rapeseed oil gums by response surface methodology. Industrial Crops and Products, 2013, 42(1): 500-506.

[18] Tarocco F, Lecuona R E, Couto A S, Arcas J A. Optimization of erythritol and glycerol accumulation in conidia of Beauveria bassiana by solid-state fermentation, using response surface methodology. Applied Microbiology and Biotechnology, 2005, 68(4): 481-488.

[19] Bachir B M, Meziant L, Benchikh Y, Louaileche H. Deployment of response surface methodology to optimize recovery of dark fresh fig (Ficus carica L., var. Azenjar) total phenolic compounds and antioxidant activity. Food Chemistry, 2014, 162(11): 277-282.

[20] Chanukya B S, Kumar M, Rastogi N K. Optimization of lactic acid pertraction using liquid emulsion membranes by response surface methodology. Separation and Purification Technology, 2013, 111: 1-8.

[21] 李银平. 防治蓟马的白僵菌剂型及应用技术研究[D]. 北京: 中国农业科学院, 2012.

Li Y P. Research on Beaveria bassiana formulations and application technology for thrips control[D]. Beijing: Chinese Academy of Agricultural Sciences, 2012. (in Chinese)

[22] Dong S, Chi N Y, Zhang Q F. Optimization of culture conditions for cold-active cellulose production by Penicillium cordubense D28 using response surface methodology. Advanced Materials Research, 2011, 3(183/185): 994-998.

[23] Muralidhar R V, Chirumamila R R, Marchant R, Nigam P. A response surface approach for the comparison of lipase production by Candida cylindracea using two different carbon sources. Biochemical Engineering Journal, 2001, 9(1): 17-23.

[24] 李增智. 球孢白僵菌的昆虫寄主名录//中国虫生真菌研究与应用. 北京: 学术期刊出版社, 1986: 241-255.

Li Z Z. A check list of the insect hosts of Beaveria bassiana//Chinese Insect Fungi Research and Application. Beijing: Academic Journal Press, 1986: 241-255. (in Chinese)

[25] 孙佰平, 任娟, 赵思峰, 侯彩霞, 王斌, 刘启鹏. 响应面法优化球孢白僵菌CXJ-1的发酵工艺条件. 石河子大学学报: 自然科学版, 2011, 29(6): 689-695.

Sun B P, Ren J, Zhao S F, Hou C X, Wang B, Liu Q P. Optimization of fermentation conditions for Beaveria bassiana CXJ-1 spore by response surface methodology. Journal of Shihezi University: Natural Science, 2011, 29(6): 689-695. (in Chinese)